Zippy Tech. HG2 Manual de usuario

Advance Technologies; Automate the World.Manual Rev. 2.20Revision Date: August 30, 2010Part No: 50-15064-1020cPCI-3920 Series3U CompactPCI Blade wi

xList of TablesThis page intentionally left blank.

88 BIOS Setup UtilityDisabled Set this value to prevent the use of any USB devicein DOS or during system boot. Enabled Set this value to allow the us

BIOS Setup Utility 89cPCI-39207.4 PCI/PnP SetupSelect the PCI/PnP tab from the setup screen to enter the Plugand Play BIOS Setup screen. You can disp

90 BIOS Setup Utilitydevice. Reserved – This setting allows the specified DMA to beused by a legacy ISA device.7.5 Boot SetupSelect the Boot tab from

BIOS Setup Utility 91cPCI-3920Boot Setting ConfigurationUse this screen to select options for the Boot Settings Configura-tion. Use the up and down &

92 BIOS Setup UtilityBoot Device PriorityBoot Devices PriorityThis specifies the boot sequence from the available devices.The 1st Boot Device is prima

BIOS Setup Utility 93cPCI-3920Removable DrivesRemovable DrivesThis specifies the Boot Device Priority sequence from availableRemovable Drives. Disabl

94 BIOS Setup Utility7.6 Security SetupPassword SupportTwo Levels of Password ProtectionProvides both a Supervisor and a User password. If you useboth

BIOS Setup Utility 95cPCI-3920Remember the PasswordKeep a record of the new password when the password ischanged. If you forget the password, you mus

96 BIOS Setup UtilityChange User PasswordSelect Change User Password from the Security Setup menu andpress < Enter >.Enter New Password: Type th

BIOS Setup Utility 97cPCI-39207.7 Chipset SetupSelect the Chipset tab from the setup screen to enter the ChipsetBIOS Setup screen. You can select any

List of Figures xicPCI-3920List of FiguresFigure 1-1: cPCI-3920 Block Diagram ... 3Figure 2-1: cPCI-3920 Mecha

98 BIOS Setup Utility82571EB PCIE connect toSet the onboard LAN to connect to either J2/RTM or Front I/O.The settings are RTM (J2) and GigaLAN (Front

BIOS Setup Utility 99cPCI-39207.8 Exit MenuSelect the Exit tab from the setup screen to enter the Exit BIOSSetup screen. You can display an Exit BIOS

100 BIOS Setup UtilityDiscard Changes and ExitSelect this option to quit Setup without making any permanentchanges to the system configuration. Discar

Important Safety Instructions 101cPCI-3920Important Safety InstructionsPlease read and follow all instructions marked on the product andin the docume

102 Important Safety InstructionsX Openings in the case are provided for ventilation. Do notblock or cover these openings. Make sure there is adequate

Getting Service 103cPCI-3920Getting ServiceContact us should you require any service or assistance. ADLINK Technology, Inc. Address: 9F, No.166 Jia

104 Getting ServiceADLINK Technology (Europe) GmbH Address: Nord Carree 3, 40477 Duesseldorf, Germany Tel: +49-211-495-5552 Fax: +49-211-495-5557

xii List of FiguresThis page intentionally left blank.

Overview 1cPCI-39201Overview1.1 IntroductionThe cPCI-3920 is a highly integrated 3U CompactPCI SBC in sin-gle slot (4HP) or dual slot (8HP) width for

2Overview1.2 FeaturesX 3U CompactPCI SBC in 4HP or 8HP width form factorX Low power Intel Core 2 Duo 1.5GHz, Core™ Duo 1.2GHz, Celeron® M 1.0GHz proc

Overview 3cPCI-39201.3 Block DiagramFigure 1-1: cPCI-3920 Block Diagram Intel® Core 2 Duo(Merom)FSB533/677USBCOM 1/2LPCPCI 32-bit/33MHzPCI-E x4 (1x)

4Overview1.4 Product ListProducts included in the cPCI-3920 Series include:SBCX cPCI-3920A: single-slot (4HP) width 3U CompactPCI fea-turing Intel LV

Overview 5cPCI-39201.5 Package Contents The cPCI-3920 is packaged with the following components. If anyof the items on the contents list are missing

6OverviewThis page intentionally left blank.

Specifications 7cPCI-39202 Specifications2.1 CPU, memory, and chipset2.2 InterfacesProcessoruFC-BGA Intel® Core™ 2 Duo LV (L7400) 1.5 GHz, FSB 667MHz

Revision HistoryRevision Release Date Description of Change(s)2.00 2008/07/07 Initial Release2.10 2008/09/04 Update BIOS chapter2.20 2010/08/30Correct

8 SpecificationsSerial Port4x serial portsTwo DB-9 ports on the front panel, one RS-232 and one RS-232/422/485/485+ (8HP only)Two ports are routed to

Specifications 9cPCI-39202.3 Software 2.4 Mechanical2.5 EnvironmentalBIOS AMI 16Mbit FWHSupported OSMicrosoft® Windows® XP ProfessionalMicrosoft® Win

10 Specifications2.6 I/O Connectivity TableTable 2-1: I/O ConnectivitycPCI-3920A cPCI-3920B cPCI-R3920(T)Faceplate Board Faceplate Board FaceplateGbE

Specifications 11cPCI-39202.7 Power RequirementsIn order to guarantee a stable functionality of the system, it is rec-ommended to provide more power

12 SpecificationsPower ConsumptionThe following tables provide information on the power consump-tion of cPCI-3920.Processor: Intel® Core™ 2 Duo LV (L7

Specifications 13cPCI-3920Processor: Intel® Core™ Duo (U2500) 1.2GHz, FSB 533MHz, 2MB L2 cacheTable 2-4: Power consumption of Core™ 2 Duo LV (U2500)

14 SpecificationsProcessor: Intel® Celeron M LV(423) 1.07GHz, FSB 533MHz, 1MB L2 cacheTable 2-5: Power consumption of Celeron M LV(423)Function Conf

Specifications 15cPCI-39202.8 Mechanical DimensionscPCI-3920AcPCI-3920BFigure 2-1: cPCI-3920 Mechanical Dimensions

16 SpecificationscPCI-R3920cPCI-R3920TFigure 2-2: cPCI-R3920 Mechanical Dimensions

Specifications 17cPCI-39202.9 Board LayoutcPCI-3920 Board LayoutFigure 2-3: cPCI-3920 Board LayoutU6 Processor CN2 USB portU7 Chipset CN3 VGA portU5

Preface iiicPCI-3920PrefaceCopyright 2010 ADLINK Technology Inc.This document contains proprietary information protected by copy-right. All rights ar

18 SpecificationscPCI-3920A Assembly OutlinecPCI-3920A Front PanelFigure 2-4: cPCI-3920A Assembly and Front PanelReset ButtonX RSTTemperature LEDX Hot

Specifications 19cPCI-3920DB-3920L2 Daughter Board Components LayoutThe DB-3920L2 Daughter Board extends the cPCI-3920 from4HP (cPCI-3920A) to 8HP (c

20 SpecificationscPCI-3920B Assembly OutlinecPCI-3920B Front PanelFigure 2-6: cPCI-3920B Assembly and Front Panel2.5” SATA hard drive

Specifications 21cPCI-3920cPCI-R3920(T) Board LayoutThe cPCI-3920 Series offer two version rear transition moduleswith the same functionality but dif

22 SpecificationsThis page intentionally left blank.

Functional Description 23cPCI-39203 Functional DescriptionThe following sections describe the cPCI-3920 main functions andboard interfaces.3.1 CPU, M

24 Functional DescriptionThe following list sets out some of the key features of the Intel®Core™ Duo and the Intel® Core™2 Duo processors:X Two mobile

Functional Description 25cPCI-3920agement that reduce the number of micro-ops handled by the processor.X On-die, primary 32-kB instruction cache and

26 Functional DescriptionMemoryThe cPCI-3920 supports a single soldered channel DDR2 memorywith Error Checking and Correcting (ECC) running at 400 MHz

Functional Description 27cPCI-3920PCI ExpressThe Intel 3100 Chipset provides one configurable x8 PCIExpress interface with a maximum theoretical band

iv PrefaceUsing this ManualAudience and ScopeThe cPCI-3920 User’s Manual is intended for hardwaretechnicians and systems operators with knowledge of i

28 Functional DescriptionX System TCO Reduction CircuitsX SMBusX Watchdog TimersX PCI 2.3 InterfaceX Two fully functional serial portsX 38 General Pur

Functional Description 29cPCI-3920Z Supports DDR-II SDRAM memoryZ 32 MB memory configurationZ Supports VGA BIOS auto memory size detectionX High Perf

30 Functional Description3.2 PeripheralsThe following standard peripherals are available on the cPCI-3920board:TimerThe cPCI-3920 is equipped with the

Functional Description 31cPCI-3920BatteryThe cPCI-3920 is provided with a 3.0 V “coin cell” lithium batteryfor the RTC. To replace the battery, proce

32 Functional DescriptionResetA reset will be generated by the following conditions:X Pressing the front panel reset buttonX Watchdog overflowX Compac

Functional Description 33cPCI-3920FWH Flash MemoryFor simple BIOS updating a standard onboard 16 Mbit FirmwareHub device is used. The FWH stores both

34 Functional Description3.3 Board InterfacesUSB InterfacesThe cPCI-3920 supports six USB 2.0 ports:X one front I/OX two front I/O on DB-3920L2 module

Functional Description 35cPCI-3920Onboard USB Pin Header (CN5)The onboard USB device (CN5 pin header, 2.54mm pitch) isused to connect a USB Flash Dis

36 Functional DescriptionUSB Flash Disk Mechanical LayoutX Maximum space reserved for USB flash disk is 50mm x 30mm (LxW)X The distance between the ce

Functional Description 37cPCI-3920Graphics ControllerThe Volari™ Z11 graphics controller incorporates a powerful 64-bitgraphics engine to enhance the

Preface vcPCI-3920ConventionsTake note of the following conventions used throughout thismanual to make sure that users perform certain tasks andinstr

38 Functional Descriptioninterface at 250MHz. It can support up to a 1GB/s bandwidth,with a 16-bit DDRII SDRAM interface.A DRAM capacity of 32MB is cu

Functional Description 39cPCI-3920Gigabit Connector RJ-45 Pin Definitions (CN7/CN8)The CN7/CN8 connector supplies the 10Base-T, 100Base-TX and

40 Functional Descriptionremains off, a valid link has not been established due to a miss-ing or a fault connection.Table 3-8: Ethernet LED Status De

Functional Description 41cPCI-3920CN4 Pin AssignmentTable 3-9: Board-to-Board Connector Pin DefinitionSIGNAL PIN PIN SIGNALGND 1 2 LPC_FRAME#USB3-D-

42 Functional DescriptionKeyboard/ Mouse InterfaceThe keyboard controller is located on the cPCI-3920B and is 8042software compatible.The PC/AT standa

Functional Description 43cPCI-3920Universal Serial PortsTwo PC-compatible serial RS-232, 9-pin D-Sub ports are avail-able and fully compatible wi

44 Functional DescriptionCOM4 Mode Switch SettingsTable 3-13: COM4 Mode Switch SettingsLocation SW1 SW2 SW3 SW4 RS232 Full Modem 1 ON ON OFF ON 2

Functional Description 45cPCI-3920Serial ATA InterfacesThe cPCI-3920 provides up to four SATA interfaces. Three SATAports, SATA1, SATA2 and SATA3, ca

46 Functional DescriptionSATA0 Connector, CN3-2Table 3-14: SATA0 Connector Pin DefinitionPIN SIGNAL FUNCTION I/OSignal Segment Key S1 GND Ground si

Functional Description 47cPCI-3920CompactPCI Bus InterfacesThe complete CompactPCI connector configuration comprises twoconnectors named J1 and J2. T

vi PrefaceThis page intentionally left blank.

48 Functional DescriptionCompactPCI J1 Pin AssignmentTable 3-15: CompactPCI J1 Pin AssignmentPin Z A B C D E F25 GND +5V REQ64# ENUM# +3.3V +5V GND24

Functional Description 49cPCI-3920CompactPCI J2 Pin AssignmentThe cPCI-3920 board provides Rear I/O connectivity for specialcompact systems. Some sta

50 Functional DescriptionLegend for J2 Pin AssignmentTable 3-16: CompactPCI J2 Pin AssignmentPin Z A B C D E F22N.CGA[4] GA[3] GA[2] GA[1] GA[0] GND2

Functional Description 51cPCI-39203.4 Board Interfaces on RTMThere are two identical USB interfaces on the CPCI-R3920(T)RTM, each with a maximum tran

52 Functional DescriptionGigabit Connector RJ-45 Pin Definitions (CN6-R)The CN7/CN8 connector supplies the 10Base-T, 100Base-TX and 1000Base-T

Functional Description 53cPCI-3920COM1 DB-9 Serial Port Connector (CN3-R)Table 3-19: COM1 Serial Port Connector Pin DefinitionCOM2 Onboard Serial Po

54 Functional DescriptionSerial ATA Interfaces - SATA1-3The onboard Serial ATA connectors CN2-R, CN4-R and CN5-Rallow the connection of standard HDDs

Functional Description 55cPCI-3920Rear I/O Interfaces on CompactPCI Connector rJ2The cPCI-3920 Rear Transition Module conducts a wide range ofI/O sig

56 Functional DescriptionCompactPCI rJ2 Pin AssignmentLegend for rJ2 Pin AssignmentTable 3-22: CompactPCI rJ2 Pin AssignmentPin Z A B C D E F22 N.C.

Getting Started 57cPCI-39204 Getting StartedThe cPCI-3920 has been designed for easy installation. However,the following standard precautions, instal

Table of Contents viicPCI-3920Table of ContentsRevision History... iiPreface...

58 Getting Started4.2 Installing the USB Flash DiskThe cPCI-3920 supports an onboard USB Flash Disk module viathe CN5 pin header. To install a USB Fla

Getting Started 59cPCI-39204.3 Installing the Hard Disk Drive (cPCI-3290B only)The cPCI-3920B supports a slim-type 2.5” SATA HDD. If the cPCI-3920 co

60 Getting Started4.4 Installing the cPCI-3920 to the ChassisTo install the cPCI-3920 module to a CompactPCI chassis:1. Refer to the chassis documenta

Getting Started 61cPCI-39204.5 RTM (cPCI-R3920) InstallationFollow the typical cPCI board installation and removal proceduresfor the RTM. However, be

62 Getting StartedThis page intentionally left blank.

Driver Installation 63cPCI-39205 Driver InstallationThe cPCI-3920 drivers are available from the ADLINK All-In-OneCD at X:\cPCI\cPCI-3920\, or from t

64 Driver InstallationThis page intentionally left blank.

Watchdog Timer 65cPCI-39206 Watchdog Timer6.1 WDT OverviewThis section explains the operation of the cPCI-3920’s WatchdogTimer (WDT). The primary fun

66 Watchdog Timerthe internal IO to control the WDT and retrieve its status. The basicfunctions of the WDT include:X Setting the watchdog timeout inte

Watchdog Timer 67cPCI-3920void write_config_data_byte(unsigned char,unsigned char);unsigned char read_config_data_byte(unsigned char);unsigned int re

viii Table of Contents5 Driver Installation... 636 Watchdog Timer...

68 Watchdog Timeroutportb(wdt_io_base+0x18,2);//watchdog timer enable!!printf("\nPlease waiting for Watch-Dog Timer time-out!!");}/*********

Watchdog Timer 69cPCI-3920outportb(0xeb,00); //io delayoutportb(config_port_index,0x08);}/************************************/unsigned char read_con

70 Watchdog Timerunlocking_reg();outportb(wdt_io_base+5,*p_data);p_data++;// printf("%x\n",*p_data);unlocking_reg();outportb(wdt_io_base+6,*

BIOS Setup Utility 71cPCI-39207 BIOS Setup UtilityThe following chapter describes basic navigation for theAMIBIOS®8 BIOS setup utility.7.1 Starting t

72 BIOS Setup UtilitySetup MenuThe main BIOS setup menu is the first screen that you can navi-gate. Each main BIOS setup menu option is described in t

BIOS Setup Utility 73cPCI-3920These keys include < F1 >, < F10 >, < Enter >, < ESC >, < Arrow >keys, and so on. .The &l

74 BIOS Setup UtilityF10 The < F10 > key allows you to save any changes you have made and exit Setup. Press the < F10 > key to save your

BIOS Setup Utility 75cPCI-39207.2 Main SetupWhen you first enter the Setup Utility, you will enter the Main setupscreen. You can always return to the

76 BIOS Setup UtilityInput UUIDUse this function to set a unique Universally Unique Identifier(UUID) for the system.UUID Byte 0-7This field sets bytes

BIOS Setup Utility 77cPCI-39207.3 Advanced BIOS SetupSelect the Advanced tab from the setup screen to enter theAdvanced BIOS Setup screen. You can se

List of Tables ixcPCI-3920List of TablesTable 2-1: I/O Connectivity ... 10Table 2-2: CompactPC

78 BIOS Setup UtilityIntel® Core™2 Duo L7400Hardware PrefetcherThe processor has a hardware prefetcher that automaticallyanalyzes its requirements and

BIOS Setup Utility 79cPCI-3920This reduces cache latency by making the next cache lineimmediately available if the processor requires it as well.When

80 BIOS Setup UtilityCPU Frequency on XP/LinuxThis option is used to manually set the CPU frequency on XPand Linux operating systems. The following op

BIOS Setup Utility 81cPCI-3920Intel® SpeedStep™ TechologyThis allows you to enable or disable Intel® SpeedStep™ Tech-nology.Intel® Celeron® M ULV 423

82 BIOS Setup UtilityIDE ConfigurationYou can use this screen to select options for the IDE ConfigurationSettings. Use the up and down < Arrow >

BIOS Setup Utility 83cPCI-3920Primary IDE Master, Primary IDE Slave, Secondary IDE Master, Secondary IDE SlaveSelect one of the hard disk drives to c

84 BIOS Setup UtilityHardware Health ConfigurationThis option displays the current status of all of the monitored hard-ware devices / components such

BIOS Setup Utility 85cPCI-3920Remote Access ConfigurationRemote Access Configuration provides the settings to allowremote access by another computer

86 BIOS Setup UtilitySerial Port ModeSelect the baud rate you want the serial port to use for consoleredirection. The options are 115200 8,n,1; 57600

BIOS Setup Utility 87cPCI-3920USB ConfigurationYou can use this screen to select options for the USB Configura-tion. Use the up and down < Arrow &